高级检索+

PV/T耦合双源热泵供暖系统运行控制策略与示范应用

Operation control strategy and demonstration application of PV/T coupled dual source heat pump heating system

  • 摘要: 为优化北方农村清洁供暖方案,该文设计太阳能光伏光热(photovoltaic/thermal,PV/T)组件耦合双源热泵供暖系统及控制方法。首先,将北方农村建筑分类为办公建筑及生活建筑,按供热需求提供不同的控制逻辑。其次,系统集热侧采用PV/T组件与储能水箱的温差控制,并将双源热泵耦合至供暖侧,根据储能水箱温度及供暖时段切换双源热泵的启动模式。此外,系统设计储能水箱直供模式,无需启动双源热泵,最大程度减少电能消耗。最后,以金昌市龙寨村村委会、金昌市农户自建房搭建示范项目,分析典型日及72 h供暖运行数据。数据表明:龙寨村村委会,1—3月储能水箱直供次数为9次,平均供暖热功率63.50 kW,平均直供时长3.36 h。直供典型日,本系统与空气源热泵机组单独运行对比,制热量增长7.13%,耗电量下降28.95%,供暖侧能效比增长27.98%。供暖中期72 h连续运行,村委会平均集热效率41.24%,农户平均集热效率38.63%。该系统在对应的控制策略下,集热性能和供暖性能有较好表现,具有较高的工程推广价值。

     

    Abstract: In response to achieve carbon peaking and carbon neutrality goals, reduce the energy consumption of traditional dual source heat pumps, optimize and accelerate the promotion of clean heating solutions, this paper proposed a solar photovoltaic thermal (PV/T) module coupled dual source heat pump heating system. The system consisted of four main parts: heat collection side, water source side, heating side, and power generation side. The collection side equipment included PV/T components and cooling tower, the water source side included heat storage tank, the heating side included dual source heat pump system, and the power generation side included power electronic devices such as inverter. Firstly, according to energy demand, rural buildings in northern China were divided into rural office buildings and rural living buildings, and the operating periods of dual source units were matched based on heating demand to maximize the COP of the units. Secondly, during the heating season, the heat collection side utilized the temperature difference between PV/T components and heat storage tank to achieve heat collection control and collect solar energy heat. During non heating season, use cooling towers to cool down PV/T components and control their temperature within a range with high photoelectric conversion efficiency. thirdly, the heat collected by the heat storage tank serveed as the primary heat source for the water source heat pump, converting low-temperature heat sources into high-temperature heat sources for end of pipe heating. When the temperature of the heat storage tank was low, switch to the air source heat pump for end of pipe heating. The most important thing was that when the temperature of the heat storage tank exceeds 45 ℃, the heat storage tank directly heated the end of the line without starting the dual source heat pump, minimizing power consumption to the greatest extent possible. The power generation side adopted the "self production and self use, surplus power grid connection" mode. During the heating season, the self generated part was given priority to supply power to the system equipment. During non heating season, power generation on the power generation side was integrated into the grid to increase system revenue. Finally, using Longzhai Village Committee and self built houses by farmers in Jinchang City as supply buildings, a demonstration project will be constructed to analyze typical daily heating and 72 hour continuous heating operation data. Data shows that from January to March, the Longzhai Village Committee had a total of 9 times of direct heating from the water tank, with an average heating power of 63.50kW and an average direct water supply time of 3.36 h. On typical days of direct supply, compared with the operation of air source heat pump units alone, this system increased heating capacity by 7.13%, reduced power consumption by 28.95%, and increased heating side energy efficiency by 27.98%. During the mid-term heating period of continuous operation for 72 hours, the average heat collection efficiency of public buildings is 44.42%, and the photoelectric conversion efficiency is 15.17%. The average heat collection efficiency of living buildings is 38.63%, and the photoelectric conversion efficiency is 15.46%. This system has good performance in heat collection, power generation, and heating, and has high engineering promotion value.

     

/

返回文章
返回